SILICONE

Material Safety Data Sheet

MSDS Preparer's Information

Alternate Vendors

Vendor #1 CAGE

0KND3

`Specification Number`	`NR`
`Appearance/Odor`	`THICK PASTE, SLIGHT VINEGAR ODOR`
`Boiling Point`	`NR`
`Vapor Pressure`	`< 5 MM HG`
`Vapor Density`	`2.07`
`Specific Gravity`	`1.04`
`Evaporation Rate`	`N/A`
`Solubility in Water`	`MODERATE`
`Percent Volatiles by Volume`	`3.8`
`Chemical pH`	`3-5`
`Container Pressure Code`	`4`
`Temperature Code`	`8`
`Product State Code`	`L`

`Flash Point Method`	`UNK`
`Lower Explosion Limit`	`N/A`
`Upper Explosion Limit`	`N/A`
`Extinguishing Media`	`WATER SPRAY, CO2, DRY CHEMICAL, FOAM, SAND`
`Special Fire Fighting Procedures`	`USE SELF CONTAINED BREATHING APPARATUS OPERATED IN POSITIVE FLOW`
`Unusual Fire/Explosion Hazards`	`TOXIC GASES & AEROSOL MAY PRODUCE BY COMBUSTION E,G. CO, SIO`

`Stability`	`YES`
`Stability Conditions to Avoid`	`RELEASE SMALL AMOUNTS OF ACID ON EXPOSURE TO MOISTURE`
`Materials to Avoid`	`PROLONGED CONTACT W/MOISTURE DURING STORAGE`
`Hazardous Decomposition Products`	`ACETIC ACID FROM MOISTURE; CO, VOLATILE ORGANICS & SILICA AEROSOIS FROM THERMAL`
`Hazardous Polymerization`	`NO`
`Polymerization Conditions to Avoid`	`WILL NOT OCCUR`
`LD50 - LD50 Mixture`	`NR`

`Route of Entry: Skin`	`YES`
`Route of Entry: Inhalation`	`YES`
`Health Hazards - Acute and Chronic`	`SEVERE IRRITATION TO RESPIRATORY TRACT, PULMONARY EDEMA, EYE LACRIMATION, CORNEAL EDEMA; SKIN IRRITATION & DERMATITIS. BRONCHITIS, LARYNGITIS, DERMATITIS CONJUNCTIVITIS`
`Carcinogenity: NTP`	`NR`
`Carcinogenity: IARC`	`NR`
`Carcinogenity: OSHA`	`NR`
`Symptoms of Overexposure`	`IRRITATION TO SKIN, EYES AND MUCOUS MEMBRANES. MAY CAUSE DISCOMFORT, TEARING, CHOKING, BURNING SENSATION`
`Medical Cond. Aggrevated by Exposure`	`RESPIRATORY, SKIN OR EYE DISEASES`
`Emergency/First Aid Procedures`	`EYES: FLUSH WITH WATER FOR >15 MIN, WHILE LIFTING EYE LIDS. SKIN: WASH W/SOAP & WATER. INHALE: REMOVE TO FRESH AIR`

`Steps if Material Released/Spilled`	`MATERIALRELEASES ACETIC ACID ON EXPOSURE TO AIR. PROVIDE ADEQUATE VENTILATION DURING CLEAN UP. WEAR PROPER PROTECTIVE EQUIP. IF HANDLING LG AMTS. TRANSFER TO A WASTE CONTAINER. LET CURE TO SOLID RUBBER, ALLOWING ALL LIBERATED ACETIC ACID TO DISSIPATE`
`Waste Disposal Method`	`DISPOSE OF IN ACCORDANCE TO ALL STATE AND FEDERAL LAWS`
`Handling and Storage Precautions`	`AVOID PROLONGED SKIN CONTACT. LIBERATED ACETIC ACID VAPORS CAUSE IRRITATION TO SKIN, EYES ADN BRONCHIAL TISSUES. DO NOT INGEST`
`Other Precautions`	`WASH BEFORE EATING, DRINKING, SMOKING. DO NOT RUB EYES WHILE WORKING W/SEALANT`

`Respiratory Protection`	`IF VENTILATION IS INADEQUATE,USE NIOSH APPROVED CHEMICAL CARTRIDGE RESPIRATOR WITH FULL FACE PIECE & ORGANIC VAPOR CARTRIDGE`
`Ventilation`	`RECOMMENDED 10 AIR CHANGES PER HOUR`
`Protective Gloves`	`DISPOSABLE PLASTIC,RUBBER OR NEOPRENE`
`Eye Protection`	`SAFETY GLASSES OR GOGGLES`
`Other Protective Equipment`	`NONE`
`Work Hygenic Practices`	`WASH WITH SOAP AND WATER AFTER HANDLING, BEFORE EATING, DRINKING, SMOKING. DO NOT RUB EYES WHILE WORKING W/SEALANT`
`Supplemental Health/Safety Data`	`WASH BEFORE EATING,DRINKING,OR SMOKING`
`Disposal Code`	`O`

`Protect Eye`	`YES`
`Protect Skin`	`YES`
`Protect Respiratory`	`YES`
`Chronic Indicator`	`YES`
`Contact Code`	`MODERATE`
`Fire Code`	`UNKNOWN`
`Health Code`	`UNKNOWN`
`React Code`	`UNKNOWN`
`Specific Hazard and Precaution`	`SEVERE IRRITATION TO RESPIRATORY TRACT, PULMONARY EDEMA, EYE LACRIMATION, CORNEAL EDEMA, SKIN IRRITATION, DERMATITIS, BRONCHITIS, LARYNGITIS, DERMATITIS, CONJUCTIVITIS`

`Container Quantity`	`2.8`
`Unit of Measure`	`OZF`

`Volatile Organic Compounds (P/G)`	`.4`
`Volatile Organic Compounds (G/L)`	`47.9355`

`Ingredient #`	`01`
`Ingredient Name`	`METHYLTRIACETOXYSILANE (2-6%)`
`CAS Number`	`4253343`
`Proprietary`	`NO`
`Percent`	`6`
`OSHA PEL`	`N/A`
`ACGIH TLV`	`N/A`
`Ingredient #`	`02`
`Ingredient Name`	`ETHYLTRIACETOXYSILANE (2-6%)`
`CAS Number`	`17689779`
`Proprietary`	`NO`
`Percent`	`6`
`OSHA PEL`	`N/A`
`ACGIH TLV`	`N/A`
`Ingredient #`	`03`
`Ingredient Name`	`DIHYDROXYPOLYDIMETHYLSILOXANE`
`CAS Number`	`70131678`
`Proprietary`	`NO`
`Percent`	`0`
`OSHA PEL`	`N/A`
`ACGIH TLV`	`N/A`
`Ingredient #`	`04`
`Ingredient Name`	`POLYDIMETHYLSILOXANE FLUID`
`CAS Number`	`63148629`
`Proprietary`	`NO`
`Percent`	`0`
`OSHA PEL`	`N/A`
`ACGIH TLV`	`N/A`
`Ingredient #`	`05`
`Ingredient Name`	`AMORPHOUS SILICA, FUMED`
`CAS Number`	`7631869`
`Proprietary`	`NO`
`Percent`	`0`
`OSHA PEL`	`80 MG/M3`
`ACGIH TLV`	`N/A`