EXTERIOR/INTERIOR ENAMEL ALKYD GLOSS

Material Safety Data Sheet

`Item Name`
`Part Number/Trade Name`	`PROD CODE 7803 EXTERIOR/INTERIOR ALKYD GLOSS`
`National Stock Number`	`8010005273199`
`CAGE Code`	`03UL4`
`Part Number Indicator`	`A`
`MSDS Number`	`192976`
`HAZ Code`	`B`

MSDS Preparer's Information

`Date MSDS Prepared/Revised`	`27JUN02`
`Active Indicator`	`Y`

Alternate Vendors

SECTION III - Physical/Chemical Characteristics

`Hazard Storage Compatibility Code`	`NR`
`NRC License Number`	`NR`
`Net Propellant Weight (Ammo)`	`NR`
`Appearance/Odor`	`COLORED LIQUID WITH AN ALIPHATIC ODOR`
`Boiling Point`	`235-410F`
`Melting Point`	`NR`
`Vapor Pressure`	`NR`
`Vapor Density`	`>AIR`
`Specific Gravity`	`0.98`
`Decomposition Temperature`	`NR`
`Evaporation Rate`	`< ETHER`
`Solubility in Water`	`INSOLUBLE`
`Percent Volatiles by Volume`	`54.482`
`Chemical pH`	`NR`
`Corrosion Rate`	`NR`
`Container Type`	`R`
`Container Pressure Code`	`1`
`Temperature Code`	`4`
`Product State Code`	`L`

`Flash Point`	`105`
`Flash Point Method`	`SCC`
`Lower Explosion Limit`	`1`
`Upper Explosion Limit`	`7`
`Extinguishing Media`	`FOAM, ALCOHOL FOAM, CO2, DRY CHEMICAL`
`Special Fire Fighting Procedures`	`FULL PROTECTIVE EQUIPMENT, INCLUSING SCBA SHOULD BE USED. WATER MAY BE USED TO COOL CLOSED CONTAINERS TO PREVENT PRESSURE BUILDUP AND POSSIBLE AUTO-IGNITION OR EXPLSOION, WHEN EXPOSED TO EXTREME HEAT. AVOID SPREADING BURNING LIQUID QITH WATER`
`Unusual Fire/Explosion Hazards`	`KEEP CONTAINERS TIGHTLY CLOSED. ISOLATE FROM HEAT, ELECTRICAL EQUIPMENT, SPARKS AND OPEN FLAME. CLOSED CONTAINERS MAY EXPLODE WHEN EXPOSED TO EXTREME HEAT. DURING EMERGENCY CONDITIONS, OVER EXPOSURE TO DECOMPOSITON PRODUCTS MAY CAUSE A HEALTH HAZARD`

`Stability`	`N/K`
`Stability Conditions to Avoid`	`EXTREME, HEAT, SPARKS OR OPEN FLAMES`
`Materials to Avoid`	`STRONG OXIDIZING AGENTS`
`Hazardous Decomposition Products`	`IMCOMPLETE COMBUSTION CAN PRODUCE CARBON MONOXIDE`
`Hazardous Polymerization`	`NO`
`Polymerization Conditions to Avoid`	`WILL NOT OCCUR`
`LD50 - LD50 Mixture`	`NR`

`Route of Entry: Skin`	`YES`
`Route of Entry: Ingestion`	`YES`
`Route of Entry: Inhalation`	`YES`
`Health Hazards - Acute and Chronic`	`[EYE] SEVERE IRRITATION, REDNESS, TEARING AND BLURRED VISION [SKIN] FREQUENT OR PROLONGED EXPOSURE CAN CAUSE MODERATE IRRITATION, DEFATTING AND DERMATITIS. [INHAL] EXCESSIVE INHALATION OF VAPORS CAN CAUSE NASAL AND RESPIRATORY IRRITATION, DIZZINESS, WEAKNESS, FATIQUE, NAUSEA, HEADACHE. HIGH CONCENTRATIONS MAY RESULT IN NARCOSIS, CNS DEPRESSION. [INGEST] CAN CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITING AND DIARRHEA. ASPIRATION OF MATERIAL INTO LUNGS CAN CAUSE CHEMICAL PNEUMONITIS`
`Carcinogenity: NTP`	`NO`
`Carcinogenity: IARC`	`NO`
`Carcinogenity: OSHA`	`NO`
`Explanation of Carcinogenity`	`NONE`
`Symptoms of Overexposure`	`SEE ABOVE`
`Medical Cond. Aggrevated by Exposure`	`NR`
`Emergency/First Aid Procedures`	[EYE] FLUSH WITH CLEAN, LUKEWARM WATER FOR AT LEAST 15 MIN, LIFT LIDS. OBTAIN MEDICAL ATTENTION. [SKIN] REMOVE CONTAMINATED CLOTHING. WASH AFFECTED SKIN AREAS THOROUGHLY WITH SOAP AND WATER. WASH CONTAMINATED CLOTHING THOROUGHLY BEFORE REUSE. [INHAL] REMOVE CONTAMINATED CLOTHING. WASH AFFECTED SKIN AREAS THOROUGHLY WITH SOAP AND WATER. WASH CONTAMINATED CLOTHING THOROUGHLY BEFORE REUSE. [INHAL] REMOVE TO FRESH AIR. APPLY ARTIFICIAL RESPIRATION OR ADMINISTER OXYGEN AS NECESSARY. CALL A PHYSICIAN IMMEDIATELY. [INGEST] KEEP PERSON WARM QUIET AND GET IMMEDIATE MED ATTEN. DO NOT INDUCE VOMITING

`Steps if Material Released/Spilled`	`VENTILATE AREA. REMOVE ALL SOURCES OF IGNITION. AVOID SKIN CONTACT AND BREATHING VAPORS. CONTAIN AND REMOVE WITH INERT ABSORBENT AND NON-SPARKING TOOLS. REMOVE ALL NON-ESSENTIAL PERSONNEL FORM SPILL AREA`
`Neutralizing Agent`	`NR`
`Waste Disposal Method`	`DO NOT ALLOW TO ENTER GROUND WATER SYSTEMS. ABSORB LARGE SPILLS WITH SAND, CLAY OR DIATOMACEOUS EARTH. DISPOSE IN ACCORDANCE WITH LOCAL, STATE AND FEDERAL REGULATIONS`
`Handling and Storage Precautions`	`STORE IN A COOL WELL VENTILATED AREA AWAY FROM SOURCES OF IGNITION. STORE LARGE QUANTITIES ONLY IN BUILDINGS DESIGNED TO COMPLY WITH OSHA 1910.106`
`Other Precautions`	`DO NOT TAKE INTERNALLY. KEEP OUT OF REACH OF CHILDREN`

`Respiratory Protection`	`WEAR A PROPERLY FITTED NIOSH/MSHA APPROVE VAPOR/PARTICULATE RESPIRATOR OR AN AIR SUPPLYING RESPIRATOR UNLESS VENTILATION IS SUFFICIENT TO KEEP AIRBORN CONTAMINATION BELOW EXPOSURE LIMITS`
`Ventilation`	`SUFFICIENT IN VOLUME AND PATTERN WITH EXPLOSION PROOF EQUIPMENT TO KEEP AIR CONTAMINAT CONCENTRATIONS BELOW EXPOSURE LIM`
`Protective Gloves`	`RUBBER OR NEOPRENE`
`Eye Protection`	`CHEMICAL SAFETY GOGGLES OR FACE SHIELD`
`Other Protective Equipment`	`OVERALLS, GLOVES AND HOOD EYE BATH AND SAFETY SHOWER`
`Work Hygenic Practices`	`NR`
`Supplemental Health/Safety Data`	`NR`

`Protect Eye`	`YES`
`Protect Skin`	`YES`
`Protect Respiratory`	`YES`
`Chronic Indicator`	`YES`
`Contact Code`	`SLIGHT`
`Fire Code`	`UNKNOWN`
`Health Code`	`UNKNOWN`
`React Code`	`UNKNOWN`
`Specific Hazard and Precaution`	`TARGET ORGANS: KIDNEY, LIVER`

`Container Quantity`	`1`
`Unit of Measure`	`QT`

`Volatile Organic Compounds (P/G)`	`3.14`
`Volatile Organic Compounds (G/L)`	`376.2939`

`Ingredient #`	`01`
`Ingredient Name`	`RULE 66 MINERAL SPIRITS`
`CAS Number`	`64742478`
`Proprietary`	`NO`
`Percent`	`26`
`OSHA PEL`	`100 PPM`
`ACGIH TLV`	`100 PPM`
`Ingredient #`	`02`
`Ingredient Name`	`SOLVENT NAPHTHA, PETROLEUM, LIGHT AROM`
`CAS Number`	`64742956`
`Proprietary`	`NO`
`Percent`	`3`
`OSHA PEL`	`100 PPM`
`ACGIH TLV`	`NE`
`Ingredient #`	`03`
`Ingredient Name`	`BENZENE, DIMETHYL-`
`CAS Number`	`1330207`
`Proprietary`	`NO`
`Percent`	`5.1`
`OSHA PEL`	`100 PPM`
`ACGIH TLV`	`100 PPM`
`Ingredient #`	`04`
`Ingredient Name`	`BENZENE, ETHYL-`
`CAS Number`	`100414`
`Proprietary`	`NO`
`Percent`	`7.1`
`OSHA PEL`	`NE`
`ACGIH TLV`	`100 PPM`